Product ID:ISOPROPYL ALCOHOL,TECH
MSDS Date:05/01/1993
FSC:6810
NIIN:00-753-4993
MSDS Number: BFNGM

Emergency Phone: 714-864-2310

Info Phone: 714-864-2310

Preparer: C.A. EISENHARD

Cage: 60777

Telephone: 408-435-8700/800-424-9300(CHEMTREC)

Cage: 0AN91

ISOPROPYL ALCOHOL (SARA III)

CAS: 67-63-0

RTECS: NT8050000

Fraction By Weight: 99%

OSHA PEL 400 PPM/500 STEL

ACGIH TLV: 400 PPM/500STEL;9192

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:INHALATION, IRRITATION OF THE NOSE &
THROAT. HIGHER CONCENTRATIONS MAY CAUSE HEADACHES, VOMITING, COMA.
EVEN HIGHER CONCENTRATIONS MAY CAUSE COMA & DEATH. EYES:IRRITATION,
CORNEAL BURNS. SKIN:DRYNESS POSSIBLE DERMATITIS. ENGESTION:LARGE
AMOUNTS CAUSE HEADACHE, NAUSEA, VOMITING, STOMACH CRAMPS,
UNCONSCIOUSNESS, DEATH.
Explanation of Carcinogenicity:MANUFACTURER GAVE NO COMMENTS OTHER THAN
THE REFERENCE TO THE THREE LISTINGS.
Effects of Overexposure:PROLONGED EXPOSURE TO HIGH CONCENTRATIONS MAY
CAUSE SEVERE OR FATAL CNS DEPRESSION.
Medical Cond Aggravated by Exposure:PRE-EXISTING SKIN DISORDERS, EYE
PROBLEMS OR IMPAIRED RESPIRATORY FUNCTION MAY BE SUSCEPTIBLE.

First Aid:EYE:FLUSH W/WATER 15 MIN, HOLD LIDS OPEN. SKIN:REMOVE
CONTAMINATED CLOTHING AND LAUNDER BEFORE REUSE. WASH WITH SOAP &
WATER. INHALED:REMOVE TO FRESH AIR. RESTORE/AID BREATHING AS
NEEDED. INGESTED:IMM EDIATELY GIVE 2 LARGE GLASSES OF MILK ORWATER
AND INDUCE VOMITING. (NOTHING BY MOUTH IF UNCONSCIOUS.) PREVENT
ASPIRATION. GET IMMEDIATE MEDICAL CARE.

Flash Point Method:TCC
Flash Point:=11.7C, 53.F
Lower Limits:.2.0
Upper Limits:12.7
Extinguishing Media:WATER SPRAY, DRY CHEMICAL, CARBON DIOXIDE,
ALCOHOLIC FOAM. DO NOT USE DIRECT WATER SPRAY.
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT WHEN FIGHTING FIRE. USE WATER SPRAY TO
COOL NEARBY FIRE EXPOSED CONTAINERS.
Unusual Fire/Explosion Hazard:VAPORS MAY TRAVEL AND BE IGNITED BY PILOT
LIGHTS, FLAMES, SPARKS, HEATERS, ETC. AT DISTANCES FROM THE
HANDLING POINT.

Spill Release Procedures:EXTINGUISH IGNITION SOURCES. BE SURE ALL
HANDLING EQUIPMENT IS ELECTRICALLY GROUNDED. SMALL SPILL:MOP UP &
PLACE IN DOT APPROVED CONTAINERS. LARGE SPILL:DIKE W/SOIL OR OTHER
NON-COMBUSTIBLE MATERIAL & PUMP INTO DOT CONTAINER. KEEP OUT OF
SEWERS, ETC.
Neutralizing Agent:NO INFORMATION GIVEN ON MSDS BY MFR.

Handling and Storage Precautions:KEEP AWAY FROM HEAT, SPARKS, AND OPEN
FLAMES. STORE IN COOL, DRY, WELL-VENTILATED PLACE AWAY FROM
INCOMPATIBLE MATERIAL. VENT CONTAINER FREQUENTLY.
Other Precautions:VENT MORE OFTEN IN WARM WEATHER. USE ONLY
NON-SPARKING TOOLS AND ELECTRICALLY GROUND ALL EQUIPMENT WHEN
HANDLING THIS PRODUCT. DO NOT USE PRESSURE TO EMPTY CONTAINERS.
EMPTY CONTAINERS CAN HAVE RESIDU ES, GASES & MISTS. DISPOSE
PROPERLY.

Respiratory Protection:BASED ON CONTAMINATION LEVELS IN THE WORK PLACE.
FOR EXAMPLE: HALF MASK AIR PURIFYING CARTRIDGE RESPIRATOR OR
SUPPLIED AIR RESPIRATOR.
Ventilation:LOCAL AND MECHANICAL EXHAUST RECOMMENDED.
Protective Gloves:RUBBER
Eye Protection:CHEMICAL GOGGLES UNLESS RESPIRATOER WORN
Other Protective Equipment:RUBBER APRON, RUBBER BOOTS, IMPERVIOUS
CLOTHING.ETY SHOWER.
Work Hygienic Practices:EYE WASH FOUNTAIN, QUICK DRENCH SHOWER.
Supplemental Safety and Health
KEY2:KT MSDS PREPARED BY CHEMICAL COMMODITIES' C.A. EISENHARD; BUT
LISTS VAN WATERS & ROGERS AS MFR ON CONTRACTDLA-450-93-M-AS54.

HCC:F2
NRC/State Lic Num:NONE
Boiling Pt:=82.8C, 181.F
Melt/Freeze Pt:=-88.3C, -127.F
Vapor Pres:33 DEG.C?!
Vapor Density:2.07
Spec Gravity:0.79
Evaporation Rate & Reference:3 (BUTYL ACETATE=1)
Solubility in Water:100%
Appearance and Odor:MEDICINAL ALCOHOLIC ODOR

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS, ALUMINUM, ACETALDEHYDE, CHLORINE, ETHYLENE OXIDE,
HYPOCHLORUS ACID, ALDEHYDES.
Stability Condition to Avoid:HEAT, SPARKS, AND OPEN FLAMES
Hazardous Decomposition Products:MAY LIBERATE CARBON MONOXIDE OR CARBON
DIOXIDE.
Conditions to Avoid Polymerization:WILL NOT OCCUR

Waste Disposal Methods:CONSULT APPROPRIATE FEDERAL, STATE & LOCAL
REGULATORY AGENCIES TO ASCERTAIN PROPER DISPOSAL PROCEDURES.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.